Selection Of Number Of Cable Cores With Emphasis On Sizing Parameters

Posted SEP 6 2013 by CHIRAG SINGHAL in CABLES, ENERGY AND POWER with 0 COMMENTS

Selection Of Number Of Cable Cores With Emphasis On Sizing Parameters (photo by dnvkema.com)

Dependance On Installation Site

The selection of number of cable cores basically depends on the type of system where it is going to be installed.

Generally we have two types of systems:

A perfectly balanced system and
A system with some degree of unbalance (or Unbalanced System).

Generally cable sizing includes below parameters:

Cable installation conditions and the load it will carry
Continuous current rating of the cable
Voltage drop and short circuit considerations
Earth fault loop impedance

Here, I am going to describe that how the number of cores can be selected.

3-Core Cables

These cables are used generally for a perfect balanced 3-phase system. When the currents on the 3-live wires of a 3-phase system are equal and at an exact 120° phase angle, then the system is said to be balanced. The 3-phase loads are identical in all respects with no need of aneutral conductor.

An important example of 3-phase load is electric motor and that is why, they are fed through 3-Core cables in most cases.

3.5-Core Cables

A 3-phase system may have a neutral wire. This wire allows the 3-phase system to be used athigher voltages while it will still support lower voltage single phase loads.

It is not likely in such cases that the loads will be identical, so the neutral will carry the out-of-balance current of the system. The greater the degree of imbalance, the larger the neutral current.

3-5-core cable construction (figure by mitesh-raval.blogspot.com)

When there is some degree of unbalance and the amount of fault current is very small, then 3.5 core cables are used. In these types of cables, a neutral of reduced cross section as compared to the 3-main conductors is used, which is used to carry the small amount of unbalanced currents.

4-Core Cables

When there is severe out-of-balance conditions, the amount of fault current will raise to a very high level. Generally in the case of linear loads, the neutral only carries the current due to imbalance between the phases.

4-core PVC insulated and sheathed copper conductor power cable

The non-linear loads such as switch-mode power supplies, computers, office equipment, lamp ballasts and transformers on low loads produce third order harmonic currents (Definition of Harmonics and Their Origin) which are in the phase of all the supply phases.

These currents do not cancel at the star point of a three-phase system as do normal frequency currents, but add up, so that the neutral carries very heavy third harmonic currents.

That is why the neutral of the cable feeding the equipment are not reduced and made with cross sectional area same as that of the main conductor to carry this high amount of current.

5 and 6-Core Cables

Some conditions may arrive when the amount of fault (neutral) current becomes very large than the phase currents. When the load concerned to this type of situation is fed through a multi-core cable, it is necessary to use a 5-Core or 6-Core Cable.

5-core PVC insulated and sheathed copper conductor power cable

In this condition, two (or three) conductors can be used in parallel formation to carry the high amount of generated unbalanced currents.

for your philippine electrical concerns...needs...installation...orders...safeelectrical2013@gmail.com

METRO MANILA PHILIPPINES

WIRE AND CABLE SUPPLIER IN METRO MANILA

WIRE AND CABLE SUPPLIER IN QUEZON CITY

ELECTRICAL WIRE AND CABLE SUPPLIER IN MAKATI PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN TAGUIG PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN MAKATI PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN GLOBAL CITY PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN MAKATI PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN TAGUIG PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN ALABANG PHILIPPINES

ELECTRICAL WIRE AND CABLE SUPPLIER IN GLOBAL CITY PHILIPPINES

WIRE AND CABLE SUPPLIER IN LUZON

WIRE AND CABLE SUPPLIER IN VISAYA

WIRE AND CABLE SUPPLIER IN SUBIC

WIRE AND CABLE SUPPLIER IN CLARK

WIRE AND CABLE SUPPLIER IN THE PHILIPPINES

ELECTRICAL SUPPLIER IN METRO MANILA

ELECTRICAL SUPPLIER IN QUEZON CITY

ELECTRICAL SUPPLIER IN LUZON

ELECTRICAL SUPPLIER IN VISAYA

ELECTRICAL SUPPLIER IN SUBIC

ELECTRICAL SUPPLIER IN CLARK

ELECTRICAL SUPPLIER IN PHILIPPINE INDUSTRIAL PARK

ELECTRICAL SUPPLIER IN PHILIPPINE ECONOMIC ZONE

ELECTRICAL SUPPLIER FOR PHILIPPINE FOREIGNERS

ELECTRICAL SUPPLIER FOR PHILIPPINE PROVINCES

ELECTRICAL SUPPLIER IN PHILIPPINES BATANES

ELECTRICAL SUPPLIER IN PHILIPPINES LAOAG

ELECTRICAL SUPPLIER IN PHILIPPINES CLARK

ELECTRICAL SUPPLIER IN PHILIPPINES SUBIC

ELECTRICAL SUPPLIER IN PHILIPPINES MANILA

ELECTRICAL SUPPLIER IN PHILIPPINES BATANGAS

ELECTRICAL SUPPLIER IN PHILIPPINES LEGASPI

ELECTRICAL SUPPLIER IN PHILIPPINES BORACAY

ELECTRICAL SUPPLIER IN PHILIPPINES PALAWAN

ELECTRICAL SUPPLIER IN PHILIPPINES PUERTO PRINCESA

ELECTRICAL SUPPLIER IN PHILIPPINES ILOILO

ELECTRICAL SUPPLIER IN PHILIPPINES BICOL

ELECTRICAL SUPPLIER IN PHILIPPINES CEBU

ELECTRICAL SUPPLIER IN PHILIPPINES BOHOL

ELECTRICAL SUPPLIER IN PHILIPPINES SURIGAO

ELECTRICAL SUPPLIER IN PHILIPPINES DUMAGUETE

ELECTRICAL SUPPLIER IN PHILIPPINES BACOLOD

ELECTRICAL SUPPLIER IN PHILIPPINES CAGAYAN DE ORO

ELECTRICAL SUPPLIER IN PHILIPPINES SURIGAO

ELECTRICAL SUPPLIER IN PHILIPPINES BUKIDNON

ELECTRICAL SUPPLIER IN PHILIPPINES ILIGAN

ELECTRICAL SUPPLIER IN PHILIPPINES ZAMBOANGA

ELECTRICAL SUPPLIER IN PHILIPPINES BUTUAN

ELECTRICAL SUPPLIER IN PHILIPPINES GENERAL SANTOS

ELECTRICAL SUPPLIER IN PHILIPPINES ZAMBOANGA

ELECTRICAL SUPPLIER IN PHILIPPINES DAVAO

ELECTRICAL SUPPLIER IN PHILIPPINES CAGAYAN DE ORO

ELECTRICAL SUPPLIER IN PHILIPPINES BINONDO

ELECTRICAL SUPPLIER IN MAKATI PHILIPPINES

ELECTRICAL SUPPLIER IN TAGUIG PHILIPPINES

ELECTRICAL SUPPLIER IN METRO MANILA PHILIPPINES

ELECTRICAL SUPPLIER IN MANILA PHILIPPINES

ELECTRICAL SUPPLIER IN NOVALICHES QUEZON CITY PHILIPPINES

ELECTRICAL SUPPLIER IN SAN JOSE DEL MONTE BULACAN PHILIPPINES

FOR YOUR PHILIPPINE ELECTRICAL CONCERNS...NEEDS...INSTALLATION...QUOTATION...ORDERS

KINDLY EMAIL US: SAFEELECTRICAL2013@GMAIL.COM

SAFEELECTRICALONLINE@GMAIL.COM

FOR YOUR PHILIPPINE ELECTRICAL CONCERNS...NEEDS...INSTALLATION...QUOTATION...ORDERS:

KINDLY EMAIL US: SAFEELECTRICAL2013@GMAIL.COM

SAFEELECTRICALONLINE@GMAIL.COM

FOR PHILIPPINE INQUIRIES LIKE LIGHTNING ARRESTER SUPPLY AND INSTALLATION

MOBILE NUMBERS: SMART: +63 09079522099

+63 09214026477

GLOBE: +63 09273919600

+63 09157920129

SUN: +63 9227192434

+63 09336253505

WIRELESS LANDLINE: +63 4068727

+63 4922566

LANDLINE: +63 4317553

HURRY..CALL US...NOW!!!!

THANK YOU FOR YOUR ORDERS AND INQUIRIES...

LIGHTNING ARRESTER SUPPLIER AND INSTALLER IN THE PHILIPPINES

ELECTRICAL FENCE SUPPLIER AND INSTALLER IN THE PHILIPPINES

LIGHTNING ARRESTER SUPPLIER AND INSTALLER IN METRO MANILA

ELECTRICAL FENCE SUPPLIER AND INSTALLER IN METRO MANILA

LIGHTNING ARRESTER SUPPLIER AND INSTALLER IN THE PHILIPPINE ECONOMIC ZONE

ELECTRICAL FENCE SUPPLIER AND INSTALLER IN THE PHILIPPINE ECONOMIC ZONE

LIGHTNING ARRESTER SUPPLIER AND INSTALLER IN THE VISAYA REGION

ELECTRICAL FENCE SUPPLIER AND INSTALLER IN THE VISAYAS REGION

LIGHTNING ARRESTER SUPPLIER AND INSTALLER IN THE MINDANAO

ELECTRICAL FENCE SUPPLIER AND INSTALLER IN THE MINDANAO

FOR YOUR LIGHTNING STRIKE PROTECTION...LET US HELP YOU AVOID SUCH ACCIDENTS...

BEFORE IT IS TOO LATE...BEFORE IT IS TOO LATE...

WHEN LIGHTNING STRIKE HIT YOU..

I GUARANTEE YOU..YOU'LL NEVER LIVE TO TELL YOUR EXPERIENCE...

DON'T BE THE NEXT VICTIM...PROTECT YOURSELF..YOUR FAMILY..YOUR BUSINESS AT ALL TIMES..

INSTALL A LIGHTNING ARRESTER IN YOUR PLACE...DO IT NOW BEFORE YOUR CAUGHT UNAWARE...

IF YOU HAVE LIGHTING PROTECTION INSTALLED...

YOU'LL HAVE PEACE OF MIND...YOU CAN SLEEP WELL EVEN WHEN LIGHTNING STRIKES...

YOU KNOW YOUR WELL PROTECTED...

IN YOUR HOME, IN YOUR PLACE OF BUSINESS AND IN YOUR PROPERTIES...

HURRY..CALL US...NOW!!!!

THANK YOU FOR YOUR ADVANCE ORDERS AND INQUIRIES...

"PHILIPPINE FOREIGNERS AND PHILIPPINE PROVINCES ELECTRICAL SUPPLIER

AND SERVICE PROVIDER"

"SAFE ELECTRICAL SUPPLY AND SERVICES"

Jigz Enerio - Sales/Project Coordinator

Safe Electrical Supply and Services

Registered Master Electrician PRC#00034433

Real Estate Broker PRC#0000838

Institute of Integrated Electrical Engineers(IIEE)Membership#19420

Telephone: 4068727 4922566

Telefax: 4178583 4317553

smart: 09079522099

globe: 09273919600

sun: 09227192434

Building K-415 Smilecitihomes 1 Barangay Kaligayahan

Novaliches Quezon City 1124

YAHOO MESSENGER: SAFEELECTRICALSUPPLYANDSERVICES@YAHOO.COM

SAFEELECTRICALSUPPLYANDSERVICES

WEBSITE: WWW.SAFEELECTRICALSUPPLYANDSERVICES.BLOGSPOT.COM

"The Elevator to Success is always out of order,

but one can always use the stairs"

"One does not Lead by hitting people over the Head,

that's assault not Leadership" - Eisenhower

"If You Think Education is Expensive,

count the cost of being ignorant" - Past Harvard President

"If you're gonna be thinking anyway,

you might as well think big" - Donald Trump

"Insanity, doing the same things

over and over again,

then expecting a different result" - Albert Einstein

"Small minds talk of people,

average minds talk of events,

great minds talk of ideas"

“I shall pass this way but once; any good that I can do

or any kindness I can show to any human being;

let me do it now. Let me not defer nor neglect it,

for I shall not pass this way again.”

Etienne de Grellet (1773-1855);

Quaker missionary

If you wanna make the world a better place

take a look at yourself and make a change

- Michael Jackson

"The Best things in life are FREE,

Family, Relatives, Friends, Health and most especially Time"

Our company operates in the principle of cooperation, collaboration,

joint partnership/marketing and cross promotion.

We treat our people,clients,suppliers,affiliates

subcontractors, business owners, entrepreneurs(SMALL TIME or Bigtime),

common people,sales people especially PURCHASING OFFICERS as our business partners and friends.

We operate in the principle of Win-Win in every transactions we get involved in

and our company would like to establish good long-term relationship with the client we serve...

We value and aim for REPEAT BUSINESS...and not just for a one-time transaction...

Delivery Schedule: 9am to 10pm Monday to Friday Only

OFFICE DAYS: Monday to Friday Only

9-12PM TO 1-5PM ONLY

Saturday: Lord's day "EL SHADDAI" The God who is more than enough

Sunday: Family day

10% of what the company earns, we give to the Lord,

10% of what the company earns, we give to charity,

this is the company's way of giving back part of what it earns,

to the community and above.

"It is unwise to pay too much, but it's worst to pay too little.

When you pay too much, you lose a little money - that is all...

When you pay too little, You sometimes lose everything,

Because the thing you bought or the service you acquired

was incapable of doing the thing it was bought or intended to do.

The common law of business balance

prohibits paying a little and getting a lot - it can't be done.

If you deal with the lowest bidder,

It is well to add something for the risk you run,

And if you do that,

You will have enough to pay for something better."

- JOHN RUSKIN(1819 - 1900)

"Good things aren't cheap,

and cheap things aren't good"

HEALTH TIPS HEALTH TIPS HEALTH TIPS HEALTH TIPS HEALTH TIPS HEALTH TIPS

ATTENTION: FOR ALL INDIVIDUALS ESPECIALLY THOSE AGE 40 AND ABOVE.

MEDICAL EXPERIMENT - MIRACLES WITH WATER

Japanese Sickness Association has published the following experiment with WATER.

They Claim 100% success for curing old and new diseases as follows:

1. Headache, BP, Anaemia, Arthrosis, Paralysis, Palpitation, Epilepsy and Obesity

2. Cough, Bronchitis, Asthma, and Tuberculosis

3. Meningitis and any other diseases connected with URINE and LIVER.

4. Hyper-acidity, Gastritis, Dysentery, Constipation, Piles and Diabetes

5. Any other diseases connected with Eye, Nose and Throat.

6. Irregular menstrual periods of women

METHOD OF TREATMENT AND MAINTENANCE:

1. Wake-up early morning and drink Four(4) glasses (160ml each) in an empty stomach.

Thereafter, no solids or liquids should be taken up to 45 minutes.

2. Normal breakfast can be taken after the 45 minutes time elapsed.

3. Nothing either liquid or solid should be taken for Two(2) hours after breakfast, the same as with Lunch and Dinner.

4. After Dinner nothing should be taken before bedtime or sleep.

Sick and old people will find it difficult to drink Four(4) glasses of water at an instant in the beginning, but, can increase

gradually to the recommended level in a short time period.

Experiment has proved that the following diseases have been cured on treatment of water for the period shown against them

a) Hypertension - 30 days d) Constipation - 10 days

b) Gastric Problems - 30 days e) Cancer - 6 months

c) Diabetes - 30 days f) Tuberculosis - 3 months

Those who suffering from Arthritis should try this experiment three(3) times a day for one(1) week and thereafter reduce to

once in the morning. For first few days you may experience to pass urine more than the norma, but no side effects.

THIS WILL CLEANSED YOUR BODY OF IMPURITIES AND WILL

PREVENT MANY TYPES OF DISEASES...

EXERCISE RELIGIOUSLY...

AS THE SAYING GOES "HEALTH IS WEALTH"

REMEMBER:

70% of our body is made up of water...

only 30% of our body is solid...

HEALTH IS WEALTH...

WHAT'S THE USE OF HAVING A BILLION

BUT LYING IN A BED - SICK

OR SUFFERING FROM AN ILLNESS.....

I WOULD RATHER HAVE A CLEAN BILL OF HEALTH FOR A BILLION.

WHEN YOU REACH THE AGE OF 35 EXERCISE IS A MUST...

WATCH YOUR DIET...

EXERCISE DAILY AND RELIGIOUSLY

TAKE YOUR MULTIVITAMINS TO SUPPLEMENT YOUR FOOD INTAKE....

THE BEST THINGS IN LIFE ARE FREE.....

FAMILY....RELATIVES....FRIENDS....HEALTH and most importantly TIME....

YOU ARE MORE BLESSED THAN OTHERS...

WHEN YOU HAVE BOTH YOUR EYES SO YOU CAN CLEARLY SEE

OTHERS HAVE ONLY ONE...OTHERS ARE TOTALLY BLIND...

WHEN YOU HAVE BOTH YOUR EARS SO YOU CAN CLEARLY HEAR

OTHERS HAVE ONLY ONE...OTHERS ARE TOTALLY DEAF...

WHEN YOU HAVE BOTH YOUR HANDS SO YOU CAN HOLD THINGS WELL

OTHERS HAVE ONLY ONE...OTHERS HAVE NONE...

WHEN YOU HAVE BOTH YOUR FEET SO YOU CAN WALK EASILY

OTHERS HAVE ONE...OTHERS HAVE NONE..

WHEN YOU STILL HAVE YOUR PARENTS...

OTHERS HAVE ONE...OTHERS HAVE NONE...

WHEN YOU HAVE CHILDREN...

OTHERS HAVE ONE...OTHERS HAVE NONE...

WHEN YOU HAVE A FAMILY...

SOME HAVE NONE...OTHERS TOTALLY ORPHANED

WHEN YOU ARE LIVING IN THE PHILIPPINES...A DEMOCRATIC COUNTRY..

THE WEATHER NOT THAT EXTREMELY HOT NOR COLD..

WERE PLANTS AND TREES GROW EASILY

SURROUNDED BY SEAS FULL OF FISHES AND NATURAL RESOURCES

WHEN YOU ARE OLD AND STILL LIVING WITH YOUR CHILDREN

IN SOME COUNTRIES OLD PARENTS AND PEOPLE

ARE LEFT IN THE "HOME OF THE AGED NURSING FOUNDATION"

WHEN YOU STILL HAVE YOUR JOB...WORKING IN AN AIR-CONDITIONED

ROOM..JUST CONSIDER THE CONSTRUCTION WORKERS DOING THEIR

HARD LABOR JOBS UNDER THE HEAT OF THE SUN...IGNORING THE

DANGEROUS ELEMENTS CONFRONTING THEM....

COUNT YOUR BLESSINGS...COUNT THEM ONE BY ONE...

DON'T THINK OF SAYING ANY UNKIND WORD...

THINK OF PEOPLE WHO CAN'T SPEAK,

DON'T COMPLAIN ABOUT THE FOOD YOU EAT,

SOME HAVE NOTHING.

DON'T COMPLAIN ABOUT LIFE,

PAINT A SMILE ON YOUR FACE

AND THANK GOD YOU'RE ALIVE AND STILL AROUND

LIFE IS A GIFT......

LIVE IT WELL......

SAFETY 1ST

REPEAT BUSINESS 2ND

PRAY ALWAYS IT WORKS!!!

ATTENTION: FOREIGN ELECTRICAL MANUFACTURERS AND ELECTRICAL DISTRIBUTORS

OUR COMPANY WELCOMES ELECTRICAL FOREIGN SUPPLIER/MANUFACTURER/S

WHO WOULD LIKE TO OFFER THEIR PRODUCT LINE

HERE IN THE PHILIPPINES BUT ON A CONSIGNMENT BASIS ONLY,

MEANING PAYMENT WILL BE FOR A CERTAIN PERIOD...EXAMPLE SIX(6) MONTHS TO ONE(1) YEAR,

ALL THOSE ITEMS THAT WILL NOT BE SOLD OR SLOW MOVING ITEMS WILL BE REPLACED

AND WE WILL JUST PAY FOR THOSE SOLD ITEMS

YOUR COMPANY WILL BE SHOULDERING THE FORWARDING/FREIGHT COST

OR SHIPMENT COST...

WE WILL BE IN CHARGE OF STOCKAGE,MARKETING,SALES AND AFTER SALES CONCERNS..

CONTACT,EMAIL OR CALL US IF YOUR COMPANY IS INTERESTED WITH OUR OFFER...

BY THE WAY PAYMENT WILL BE BANK TO BANK...

YOUR BANK WILL BE COORDINATING WITH OUR LOCAL BANK HERE IN THE PHILIPPINES....

CALL/EMAIL US IF YOUR COMPANY IS INTERESTED ON OUR OFFER....

"YOUR FRIENDLY PHILIPPINE FOREIGNERS AND PHILIPPINE PROVINCES ONLINE ELECTRICAL SUPPLIER"

Saturday, September 14, 2013